To get long-term stable operation of your boiler, reverse osmosis water treatment essential to the cucumber into the salt water, and before long, cucumbers will shrink due to water loss. The hearts of everyone may have questions about this and I have anything to do with the boiler? Do not worry, we'll come Secret. Cucumber Cucumber inside shrink because of the low concentration to the high concentration of salt water, because of the density difference will produce natural infiltration; Conversely, if you want a high concentration of salt off the salt, to the low concentration of water, it will need to give a pressure and let it reverse osmosis. The boiler is also true. The need to constantly replenish the boiler is running a lot of water, which may be ground water, urban sewage, chemical water ...... they contain large amounts of calcium and magnesium ions and various other impurities, if not treated will flow into the boiler, the long-term run down, very easy to form scale, boiler service life and operating efficiency will be greatly reduced. Reverse osmosis water treatment is derived. A semipermeable membrane, if the principle of reverse osmosis water treatment in a fresh and salt water only through spaced impermeable solute, the fresh water will pass through the semi-permeable membrane to one side of brine, a phenomenon called penetration. Thus, during the infiltration process, due to the rise of the liquid surface side of the brine will produce a pressure, thereby inhibiting further penetration of fresh water to the brine side. Finally, when the concentrated water from the fresh water side surface of a certain liquid level height, as well as its pressure is sufficient to offset the tendency to penetration, the liquid level of the concentrated water side will not rise. In this case, the amount of water is equal to the concentrated solution into the water through a semipermeable membrane and a concentrated solution through a semipermeable membrane leaving, they are in equilibrium. At equilibrium, the level difference H between the saltwater and freshwater represents osmotic pressure difference of these two solutions. If the fresh water into the water, then this represents the osmotic pressure of saline on this principle, it is easy to deduce if a higher applied pressure than the osmotic pressure of the concentrated water side, pure water can be saline extrusion, i.e. saline water penetration into the pure water. Thus, its penetration direction and a natural infiltration opposite, i.e. reverse osmosis. Second, the reverse osmosis water treatment workflow before flowing into the boiler feed water to the boiler through the reverse osmosis water treatment system, in a high pressure state, the raw water salinity is blocked out, the extracted water flow into the boiler for final tris, Reverse osmosis water treatment benefits we all know, the boiler fouling, not only difficult to clean, but also have a significant negative impact on operating efficiency, serious and even lead to boiler damage. Water treatment can reduce scale formation mechanisms to the greatest extent, to stifle in the cradle. For the life of the boiler, safety and operational efficiency are of great help. Fourth, pay attention to regular cleaning of RO reverse osmosis filter will be cleaned after the long run, or making internal fouling water production rate will decline, we can use chemical cleaning agents. Cleaning agents may be used with a dilute hydrochloric acid solution, citric acid, sodium bisulfite and sodium hexametaphosphate complexing agent, can be selected depending on the circumstances of the boiler.

How do gas-fired steam boilers need to be maintained when they are not in use?

Nowadays, the use of gas-fired steam boiler has become more and more frequent, and the boilers all over the country have changed the use of gas-fired boiler with each passing day. Although the domestic professional gas-fired steam boiler is stable in operation and less energy-saving and consumption-reducing in sewage discharge, it is necessary to use proper maintenance in the case of long-term non-use in order to carry out normal use. Specific gas-fired steam boiler maintenance methods in the case of not in use and see below for detailed analysis of the following:

1: dry maintenance of gas-fired steam boilers should remove the boiler water after shutdown, and then thoroughly remove and rinse the dirt from the interior. And keep the oven dry so as not to be seduced. You can dry the chamber with a light fire, but not with a fire. Also be careful to close all hand-hole piping valves and place the quicklime tray in the drum. Check the boiler at least three months without using a gas-fired steam boiler for a long time. If the quicklime in the chamber is crushed into powder, the new lime needs to be replaced immediately to ensure that the drying protection in the furnace of the gas steam cooker is not corroded by moisture.

2: in addition to dry maintenance, wet maintenance of gas-fired steam boilers can also be done by means of wet maintenance, which is to remove internal dirt after discharging the water in the furnace, and to fill the chamber with treated water and then heat it to the required temperature. The gas in the water is then discharged out of the furnace and all valves are closed. In this way, the furnace is filled with water to complete maintenance. Of course, wet maintenance should not be used in cold weather to prevent water icing and damage to the tank. It can be seen that the gas-fired steam boiler in the case of not in use is mainly dry and wet method of maintenance, which kind of specific use Maintenance method according to different site and climate conditions to make flexible choice.

Food processing industry as the foundation of human existence and life, in the face of more stringent food processing caused by boiler exhaust pollution treatment, clean type of fuel gas-fired boiler choice of various food companies.

The partnership, fast boiler for the user responsible attitude to have left a deep impression on our fireman boiler operation is not very skilled, fast deliberately sent a party of professional and technical personnel for our on-site supervision of installation, commissioning and training to ensure that the latter can operate our good boiler fireman. --customer feedback